Honda Civic manuals

Subaru Legacy BN/BS (2015-2019) Service Manual: Dtc p05a2 active grille air shutter "a" control circuit/open

DTC DETECTING CONDITION:

Immediately at fault recognition

CAUTION:

After servicing or replacing faulty parts, perform Clear Memory Mode Clear Memory Mode > OPERATION, and Inspection Mode Inspection Mode > PROCEDURE.

STEPCHECKYESNO

1.CHECK DTC.

1) Perform the Clear Memory Mode using the Subaru Select Monitor. Clear Memory Mode > OPERATION

2) Turn the ignition switch to OFF, and wait for approx. 30 seconds.

3) Turn the ignition switch to ON.

4) Check for DTC. Read Diagnostic Trouble Code (DTC)

Is P05A2 displayed in «Present fault»-

Replace the active grille shutter. Active Grille Shutter

Using the Subaru Select Monitor, perform the operation check for the active grille shutter to make sure that its open and close operation can be completed properly.

NOTE:

For detailed operation procedures, refer to the “Active Test”. Active Test

1. OUTLINE OF DIAGNOSIS

Detect for the malfunction of active grille shutter motor circuit.

Judge as NG if out of specification.

2. COMPONENT DESCRIPTION

(1)

Active grille shutter

(3)

Resistance value (k-)

(4)

Ambient air temperature (°C (°F))

(2)

Ambient sensor

3. EXECUTION CONDITION

Diagnosis 1

Secondary Parameters

Execution condition

Battery voltage

≥ 10.9 V

Diagnosis 2

Secondary Parameters

Execution condition

Battery voltage

≥ 10.9 V

Command to active grille shutter

Open or Closed

4. GENERAL DRIVING CYCLE

Always perform the diagnosis continuously.

5. DIAGNOSTIC METHOD

Diagnosis 1

Judge as NG when the following conditions are established.

Judgment Value

Malfunction Criteria

Threshold Value

Current in the motor circuit during open/close command to the active grille shutter

> 650 mA

Time Needed for Diagnosis: 2500 ms

Diagnosis 2

Judge as NG when the following conditions are established.

Judgment Value

Malfunction Criteria

Threshold Value

Current in the motor circuit during open/close command to the active grille shutter

< 10 mA

Time Needed for Diagnosis: 2500 ms

Malfunction Indicator Light Illumination: Illuminates as soon as a malfunction occurs.

Dtc p05a6 active grille air shutter "a" supply voltage circuit/open
DTC DETECTING CONDITION:Immediately at fault recognitionCAUTION:After servicing or replacing faulty parts, perform Clear Memory Mode Clear Memory Mode > OPERATION, and Inspection Mode Inspection Mod ...

Dtc p05a1 active grille air shutter "a" position sensor minimum/maximum stop performance
DTC DETECTING CONDITION:Detected when two consecutive driving cycles with fault occur.CAUTION:After servicing or replacing faulty parts, perform Clear Memory Mode Clear Memory Mode > OPERATION, and I ...

Other materials:

Assembly
1. Install each cover to the front exhaust pipe.Tightening torque:13 N·m (1.3 kgf-m, 9.6 ft-lb)2. Install the center exhaust pipe to front exhaust pipe.NOTE:Use a new gasket.Tightening torque:42.5 N·m (4.3 kgf-m, 31.3 ft-lb)3. Install the front oxygen (A/F) sensor and rear oxygen senso ...

© 2017-2024 Copyright www.sulegacy.com